Product ID:340 LASG URETHANE CATALYST SEMI GLOSS/INTERIOR
MSDS Date:09/30/1994
FSC:8010
NIIN:00F016551
MSDS Number: BWTGQ

CARDINAL INDUSTRIAL FINISHES

1329 POTRERO AVE
SOUTH EL MONTE, CA 91733-3012
US

Emergency Phone: 800-444-9274/213-283-9335

Info Phone: 818-444-9274/213-283-9335

Preparer: ROBERT H SYPOWICZ

Cage: 65860

CARDINAL INDUSTRIAL FINISHES

SOUTH EL MONTE, CA 91733 US

Telephone: 818-444-9274 OR 213-283-9335

Cage: 65860

TOLUENE-2,4-DIISOCYANATE (TDI) (SUSPECTED ANIMAL CARCINOGEN

CAS: 584-84-9

RTECS: CZ6300000

Fraction By Weight: 0.15%

OSHA PEL 0.02 PPM, CEILING

ACGIH TLV: 0.005 PPM

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

HEXAMETHYLENE DIISOCYANATE

CAS: 822-06-0

RTECS: MO1740000

Fraction By Weight: 0.15%

ACGIH TLV: 0.005 PPM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

2.36 LBS/GAL, 283 GRAMS/LITER

RTECS: 9999999VO

2-BUTANONE (METHYL ETHYL KETONE) (MEK)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 8.4%

OSHA PEL 200 PPM

ACGIH TLV: 590 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ETHYL ACETATE

CAS: 141-78-6

RTECS: AH5425000

Fraction By Weight: 5.39%

OSHA PEL 1400 MG/CUM

ACGIH TLV: 1400 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

BUTYL ACETATE (N-BUTYL ACETATE) *95-1*

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 13.01%

OSHA PEL 710 MG/CUM

ACGIH TLV: 713 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: MODERATE
IRRITATION/DERMATITIS. INHALATION: NASAL IRRITATION. INGESTION:
GASTROINTESTINAL IRRITATION. ALLERGIC SKIN/RESPIRATORY REACTION MAY
OCCUR IN SOME INDIVIDUALS. PAINT & SOLVENTS HAVE BEEN LINKED TO
LIVER ABNORMALITIES, KIDNEY & LUNG DAMAGE.
Explanation of Carcinogenicity:SEE INGREDIENTS. ACCORDING TO CARDINAL
INDUSTRIAL FINISHES, TOLUENE DIISOCYANATE IS SUSP. CARC BY OSHA,
NTP.
Effects of Overexposure:IRRITATION, REDENSS, TEARING, BLURRED VISION,
DEFATTING, HEADACHE, DIZZINESS, NAUSEA, WEAKNESS, VOMITING, LOSS OF
CONSCIOUSNESS, RASH, ITCHING, HIVES, SWELLING OF EXTREMITIES,
ASTHMA-LIKE SYMPTOMS
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY
CONDITIONS. PRE-EXISTING SKIN, LIVER & KIDNEY DISORDERS

First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN/CPR IF NECESSARY.
INGESTION: DON'T INDUCE VOMITING, KEEP WARM & QUIET. OBTAIN MEDICAL
ATTENTION IN ALL CASES.

Flash Point Method:TCC
Flash Point:24F
Lower Limits:0.9
Upper Limits:11.4
Extinguishing Media:FOAM, DRY CHEMICAL, CO2, WATER FOG
Fire Fighting Procedures:USE SELF CONTAINED BRATHING APPARATUS W/FULL
FACE PIECE OPERATED IN A PRESSURE DEMAND/OTHER POSITIVE PRESSURE
MODE.
Unusual Fire/Explosion Hazard:FLAMMABLE LIQUID. CONTAINERS MAY
DEFORM/EXPLODE WHEN EXPOSED TO EXTREME HEAT.

Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES, ABSORB LIQUID
IN ABSORBANT MATERIAL & PREVENT SPREADING TO GROUND WATER.

Handling and Storage Precautions:CONTAINERS OF THIS MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED, SINCE EMPTIED CONTAINERS RETAIN PRODUCT
RESIDUALS. OBSERVE ALL HAZARDOUS PRECAUTIONS.
Other Precautions:FOR INDUSTRIAL USE ONLY. USE ONLY W/ADEQUATE
VENTILATION.

Respiratory Protection:IF TLV OF THE PRODUCT/ANY COMPONENT IS EXCEEDED,
A NIOSH/MSHA JOINTLY APPROVED AIR SUPPLIED RESPIRATOR IS ADVISED IN
ABSENCE OF ENVIRONMENTAL CONTROL. AIR SUPPLY RESPIRATORS ARE
SUGGESTED FOR SPRAY AP PLICATION.
Ventilation:SUFFICIENT MECHANICAL (GENERAL/LOCAL EXHAUST) TO MAINTAIN
EXPOSURE BELOW TLVS
Protective Gloves:CHEMICAL/SOLVENT RESISTANT
Eye Protection:OSHA APPROVED CHEMICAL
Other Protective Equipment:SPLASH APRON, IMPERVIOUS CLOTHING, CHEMICAL
RESISTANT BOOTS, GB PROTECTIVE HAND CREAM
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS BEFORE EATING/USING REST ROOM, SMOKE IN SMOKING
AREAS ONLY
Supplemental Safety and Health

Boiling Pt:B.P. Text:171-485F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:34.5

Stability Indicator/Materials to Avoid:YES
WATER, ALCOHOLS, AMINES, ALKALIS & STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXTREME TEMPS, MOISTURE
Hazardous Decomposition Products:OXIDES OF CARBON & NITROGEN, TRACES OF
HYDROGEN CYANIDE, TOLUENE DIISOCYANATE
Conditions to Avoid Polymerization:WATER, ALCOHOLS, & AMINES

Waste Disposal Methods:LIQUID INCINERATION/SENT TO APPROVED LANDFILL IN
ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS. FLAMMABLE LIQUID
UN1263.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.